luxeon xr-tx products are led modules optimized for lighting applications requiring high efcacy led arrays mounted on a rigi d and thermally conductive substrate. these versatile building blocks feature 12 luxeon tx leds on a mcpcb substrate, electrical connectors, and are designed for ease of system integration, faster time to mar ket, and use with industry standard optics. luxeon xr-tx will become a c omplete ip66 solution when used in combination with standard third part y optics and heat sink. luxeon xr-tx high performance led modules with extreme efcacy for robust lighting designs features and benefits primary applications typical 3300 lumens with 140 lm/w efcacy at 700ma and 85c board temperature architectural a range of cct options available in 70cri (4000kC5700k) high bay & low bay 150mm length x 45mm width footprint designed for use with standard third party optics outdoor features industrys highest efcacy single die emitterluxeon tx C streetlights uses lumileds proprietary pick and place system, targeting specifc led data points to support the best light output uniformity, v f and color control C tunnel one-stop shop for simplifed supply chain and faster time to market 5 year limited warranty illumination DS160 luxeon xr-tx datasheet ?2016 lumileds holding b.v. all rights reserved. no. e335118
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. i table of contents general product information 2 product test conditions .............................................................................. 2 part number nomenclature .......................................................................... 2 lumen maintenance ................................................................................. 2 environmental compliance ........................................................................... 2 performance characteristics 3 product selection guide .............................................................................. 3 electrical and thermal characteristics .................................................................. 3 absolute maximum ratings ........................................................................... 3 characteristic curves ................................................................................ 4 spectral power distribution characteristics ............................................................. 4 radiation pattern characteristics ...................................................................... 4 color bin defnition .................................................................................. 5 mechanical dimensions 6 packaging information 6 tray dimensions 7 product packaging considerations chemical compatibility ............................................. 7
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. 2 general product information product test conditions luxeon xr-tx products are specifed using a forward dc drive current of 700ma and a board temperature, t c of 85c. the leds are electrically confgured in series which means each led is driven at equal current. the luxeon tx leds on luxeon xr-tx are tested using a dc drive current at 700ma and junction temperature, t j , of 85c. the minimum, typical and maximum performance numbers for luxeon xr-tx in this datasheet are derived from individual led measurements. the confdence level on all minimum and maximum performance parameters in this datasheet is 99% to within individual led tolerance. part number nomenclature part numbers for luxeon xr-tx follow the convention below: l 2 t 0 C a a b b 0 1 2 m 0 0 0 0 0 where: a a C designates nominal ansi cct (40=4000k, 50=5000k, 57=5700k) b b C designates minimum cri (70=70cri) therefore, a luxeon xr-tx, 4000k, 70cri will have the following part number: l 2 t 0 C 4 0 7 0 0 1 2 m 0 0 0 0 0 for luxeon xr-tx cct and cri combinations not listed in this datasheet, contact your local lumileds sales representative or technical solutions manager. lumen maintenance please contact your local sales representative or lumileds technical solutions manager for more information about the long- term performance of this product. environmental compliance lumileds llc is committed to providing environmentally friendly products to the solid-state lighting market. luxeon xr-tx is compliant to the european union directives on the restriction of hazardous substances in electronic equipment, namely the rohs directive 2011/65/eu and reach regulation (ec) 1907/2006. lumileds llc will not intentionally add the following restricted materials to its products: lead, mercury, cadmium, hexavalent chromium, polybrominated biphenyls (pbb) or polybrominated diphenyl ethers (pbde).
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. 3 performance characteristics product selection guide table 1 product performance of luxeon xr-tx at 700ma, t c =85c configuration nominal cct minimum cri [1] luminous flux [2] ( lm ) typical luminous efficacy (lm/w) part number minimum typical 12-up (12 series leds) 4000k 70 3186 3221 140 l2t0-4070012m00000 5000k 70 3202 3260 140 l2t0-5070012m00000 5700k 70 3200 3257 140 l2t0-5770012m00000 notes for table 1: 1. lumileds maintains a tolerance of 2 on cri measurements. 2. lumileds maintains a tolerance of 7.5% on luminous fux measurements. electrical and thermal characteristics table 2 electrical and thermal characteristics for luxeon xr-tx at 700ma, t c =85c part number forward voltage (v f ) [1] typical thermal resistance junction to heat sink (oc/w) typical thermal resistance junction to solder pad (oc/w) [2] minimum typical maximum l2t0-xxxx012m00000 33.00 33.25 33.60 0.9 3.0 notes for table 2: 1. lumileds maintains a tolerance of 0.1v on forward voltage measurements. 2. thermal resistance from junction to solder pad is per led. absolute maximum ratings table 3 absolute maximum ratings for luxeon xr-tx parameter maximum performance dc forward current [1,2] 1050ma peak pulsed forward current [1,3] 1200ma led junction temperature [1] (dc & pulse) 150c maximum number of boards in series 7 maximum voltage across series connection of boards [4] 250 vdc esd sensitivity iec 61000-4-2 level 4 (8/15 kv contact/air discharge) operating temperature at t c point [5] -40 to 85c led module storage temperature -40 to 105c reverse voltage (v reverse ) luxeon leds are not designed to be driven in reverse bias notes for table 3: 1. proper current derating must be observed to maintain the junction temperature below the maximum. 2. residual periodic variations due to power conversion from alternating current (ac) to direct current (dc), also called ripple, with frequencies 100hz and amplitude 15% of the maximum allowable dc forward current are acceptable, assuming the average current throughout each cycle does not exceed the maximum allowable dc forward current at the corresponding maximum junction temperature. 3. pulsed operation with a peak drive current equal to the stated peak pulsed forward current is acceptable if the pulse on-time is 5ms per cycle and the duty cycle is 50%. 4. per iec 60598-1:2014/ul 8750-2015-04-01. 5. measured at t c point next to led. see ab10 6 luxeon tx application brief for details. some manufacturers refer to t c as t s . 6. per iec 62031, ethr=1631 lux.
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. 4 characteristic curves spectral power distribution characteristics radiation pattern characteristics figure 1: typical normalized power vs wavelength for luxeon tx, 70cri at 700ma, t j =85c figure 2: typical radiation pattern for luxeon tx at 700ma, t j =85c
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. 5 color bin defnition table 4. 5-step macadam ellipse color bin defnitions for luxeon xr-tx. nominal cct color space center point (cx, cy) major axis, a minor axis, b ellipse rotation angle, 4000k single 5-step macadam ellipse 0.01565 0.00670 53.7 5000k single 5-step macadam ellipse 0.01370 0.00590 59.6 5700k single 5-step macadam ellipse 0.01243 0.00533 59.1 notes for table 4: 1. xplohgvpdldlvdrohudfhrisrdgfrrugldhvlkhC(froruvsdfh figure 3: 5-step macadam ellipse illustration for table 4
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. 6 mechanical dimensions notes for figure 4: 1. drawings are not to scale. 2. all dimensions are in millimeters. packaging information table 5 packaging information for luxeon xr-tx part number tray dimensions ( mm ) quantity per tray number of trays per box l2t0-xxxx012m00000 450 x 190 30 1 figure 4: mechanical dimensions for l2t0-xxxx012m00000
DS160 luxeon xr-tx datasheet 20160127 ?2016 lumileds holding b.v. all rights reserved. 7 tray dimensions notes for figures 5 and 6: 1. drawings are not scale. 2. all dimensions are in millimeters. product packaging considerations chemical compatibility the luxeon tx package contains a silicone overcoat to protect the led chips and extract the maximum amount of light. as with most silicones used in led optics, care must be taken to prevent any incompatible chemicals from directly or indirectly reacting with the silicone. refer to the luxeon tx application brief ab106 for guidelines on chemical compatibilities. figure 5: tray base dimensions for l2t0-xxxx012m00000 figure 6: tray cover dimensions for l2t0-xxxx012m00000
?2016 lumileds holding b.v. all rights reserved. luxeon is a registered trademark of the lumileds holding b.v. in the united states and other countries. lumileds.com about lumileds lumileds is the global leader in light engine technology. the company develops, manufactures and distributes groundbreaking leds and automotive lighting products that shatter the status quo and help customers gain and maintain a competitive edge. with a rich history of industry frsts, lumileds is uniquely positioned to deliver lighting advancements well into the future by maintaining an unwavering focus on quality, innovation and reliability. to learn more about our portfolio of light engines, visit lumileds.com . DS160 luxeon xr-tx product datasheet 20160127 neither lumileds holding b.v. nor its afliates shall be liable for any kind of loss of data or any other damages, direct, indirect or consequential, resulting from the use of the provided information and data. although lumileds holding b.v. and/or its afliates have attempted to provide the most accurate information and data, the materials and services information and data are provided as is, and neither lumileds holding b.v. nor its afliates warrants or guarantees the contents and correctness of the provided information and data. lumileds holding b.v. and its afliates reserve the right to make changes without notice. you as user agree to this disclaimer and user agreement with the download or use of the provided materials, information and data.
|
